PACTRA COATINGS INC -- PACTRA IMPERIAL ENAMELS, 15 TIGER ORANGE  -- 8010-00N068256
<pre>=====================  Product Identification  =====================

Product ID:PACTRA IMPERIAL ENAMELS, 15 TIGER ORANGE
MSDS Date:07/16/1987
FSC:8010
NIIN:00N068256
=== Responsible Party ===
Company Name:PACTRA COATINGS INC
Address:420 S 11TH AVE
City:UPLAND
State:CA
ZIP:91786
Country:US
Info Phone Num:714-946-3871
Emergency Phone Num:714-946-3871
CAGE:IO302
=== Contractor Identification ===
Company Name:PACTRA COATINGS INC
Address:420 S 11TH AVE
Box:City:UPLAND
State:CA
ZIP:91786
Country:US
Phone:714-946-3871
CAGE:IO302
Company Name:PACTRA INDUSTRIES
Address:420 S 11TH ST
Box:280
City:UPLAND
State:CA
ZIP:91786-6828
Country:US
CAGE:33777

=============  Composition/Information on Ingredients  =============

Ingred Name:ACETONE (SARA 313) (CERCLA). VP:186 @ 20C. EVAP RATE:SLOWER
    THAN ETHER. FL PT:0F,-18C.
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 25-35%
OSHA PEL:1000 PPM
ACGIH TLV:750 PPM;1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:XYLENE (SARA 313) (CERCLA). VP:5.1 @ 20C. EVAP RATE:SLOWER
    THAN ETHER. FL PT:0F,-18C.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 5-10%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:LIGROINE; (V.M.&P. NAPHTHA). (MFR'S CAS NO:8030-20-7).
    VP:15 @ 20C. EVAP RATE:SLOWER THAN ETHER. FL PT:0F,-18
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 5-10%
OSHA PEL:300 PPM
ACGIH TLV:300 PPM

Ingred Name:SOLV NAPHTHA (PETRO), LIGHT AROMATIC; (HISOL 10 (AROMATIC
    NAPHTHA)). VP:3 @ 20C. EVAP RATE:SLOWER/ETHER. FL PT:0F,-18C.
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 5%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)

Ingred Name:LACOLENE; (LACOLENE ALIPHATIC NAPHTHA). VP:38 @ 20C. EVAP
    RATE:SLOWER THAN ETHER. FL PT:0F,-18C.
CAS:64742-89-8
Fraction by Wt: 6-16%
OSHA PEL:200 PPM (MFR)
ACGIH TLV:500 PPM (MFR)

Ingred Name:PROPANE; (PROPELLANT). EVAP RATE:FASTER THAN ETHER. FL
    PT:100F,38C.
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 30%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT

Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: 8-17%
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:RESP PROT:(TC23C OR EQUIVALENT), OR LEAVE THE AREA.
RTECS #:9999999ZZ

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:EXCESSIVE INHAL OF VAPS
    CAN CAUSE NASAL & RESP IRRIT, DIZZ, WEAK, FATG, NAUS, HDCH, POSS
    UNCON & EVEN ASPHY. EYE CONT:CAN CAUSE SEV IRRIT, REDNESS, TEARING,
    BLURRED VISION. INGEST:CAN CAUS E GI IRRIT, NAUS, VOMIT, DIARR.
    SKIN CONT:CAN CAUSE IRRIT FOR SOME PERSONS. CHRONIC:RPTS HAVE ASSOC
    (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:RPTD & PRLNG OCCUP OVEREXP TO SOLVS
    W/PERM BRAIN & NERV SYS DMG. SEV OVEREXP IN LAB ANIMALS HAS ALSO
    CAUSED LIVER ABNORMS & DMG TO KIDNEYS, LUNGS & SPLEEN. INTENTIONAL
    MISUSE BY DELIBERATELY  CONCENTRATING & INHALING CONTENTS MAY BE
    HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:CAN CAUSE ALLERGIC RESPIRATORY &/OR
    SKIN REACTION.

=======================  First Aid Measures  =======================

First Aid:INHAL:REMOVE INDIVIDUAL TO FRESH AIR. IF BRTHG IS DFCLT,
    ADMIN OXYG. IF BRTHG HAS STOPPED, GIVE ARTF RESP & SEEK MED HELP.
    EYES:FLUSH W/WATER FOR AT LST 15 MINS WHILE OCCAS HOLDING EYELIDS
    OPEN. GET M ED ATTN. INGEST:DO NOT INDUCE VOMIT (ASPIR OF MATL INTO
    LUNGS CAN CAUSE CHEM PNEUM, WHICH CAN BE FATAL). KEEP PERS WARM,
    QUIET & GET MED ATTN/POIS CTL CTR. SKIN:WASH W/SOAP & WATER/VARIOUS
    (SUPDAT)

=====================  Fire Fighting Measures  =====================

Flash Point:0F,-18C
Lower Limits:1%
Extinguishing Media:"ALCOHOL" FOAM, CO*2 DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP .
    WATER SPRAY MAY BE INEFT. WATER MAY BE USED TO COOL CLSD CNTNRS TO
    PVNT PRESS BUILD-UP & POSS (SUPP DATA)
Unusual Fire/Explosion Hazard:EXTREMELY FLAMM. CLSD CNTNRS MAY EXPLODE
    &/OR AUTOIGNITE WHEN EXPOS TO EXTREME HEAT. VAPS ARE HVR/AIR & MAY
    TRAVEL ALONG GROUND/MAY BE MOVED BY VENT & (SUPDAT)

==================  Accidental Release Measures  ==================

Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. VENTILATE
    AREA. ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR ABSORBENT OR OTHER
    ABSORBENT MATERIAL & TRANSFER TO A CLOSED CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:DO NOT STORE IN AREAS ABOVE 120F, OR
    IN DIRECT SUNLIGHT, OR NEAR HEAT OR OPEN FLAMES. DO NOT PUNCTURE OR
    INCINERATE.
Other Precautions:STORE LG QUANTITIES IN BUILDINGS PROTECTED FOR
    STORAGE OF NFPA CLASS IC FLAMMABLE LIQUIDS. AS W/ALL CHEMS, MIN
    PERS CONT & BRTHG OF VAPS. WHERE SPECIAL/UNUSUAL CNDTNS EXIST, THE
    EXPERT ASSISTANCE OF A N INDUSTRIAL HYGIENIST SHOULD BE SOUGHT.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:FOR CASUAL/OCCAS USE - TO AVOID BRTHG VAPS/SPRAY
    MIST, OPEN WINDOWS & DOORS/USE OTHER MEANS TO ENSURE FRESH AIR
    ENTRY DURING APPLICATION & DRYING. IF YOU EXPER EYE WATERING,
    HDCHS/DIZZ, INCR FRESH AIR , WEAR NIOSH/MSHA RESP PROT (ING 8)
Ventilation:FOR REGULAR/CONTINUOUS USE - PROVIDE SUFFICIENT MECH (GEN)
    &/OR LOC EXHST VENT TO MAINTAIN EXPOS BELOW TLV'S.
Protective Gloves:CHEM RESIST GLOVES, SUCH AS NEOPRENE.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
    ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING WASHROOM.
Supplemental Safety and Health
MP:>1500F,>816C. FIRE FIGHT PROC:AUTOIGNIT/EXPLO WHEN EXPOS TO EXTREME
    HEAT. IF WATER IS USED, FOG NOZZ ARE PREF. EXPLO HAZ:IGNITED BY
    PILOT LIGHTS, OTHER FLAMES, SPKS, HEATERS, SMOKING, ELEC MOTORS/O
    THER IGNIT SOURCES AT LOCATIONS DIST FROM MATL HNDLG POINT. FIRST
    AID PROC:HAND CLEANERS & WASH CLTHG BEFORE RE-USE.

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:>133F,>56C
Melt/Freeze Pt:M.P/F.P Text:SUPP DATA
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:<1 (H*2O=1)
Evaporation Rate &amp; Reference:SEE INGREDIENTS.
Solubility in Water:SLIGHT TO MODERATE
Appearance and Odor:TYPICAL SOLVENT PAINT.
Percent Volatiles by Volume:85-90

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZING AGENTS & HEAT.
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAME.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS, CARBON
    DIOXIDE/CARBON MONOXIDE, VARIOUS HYDROCARBONS, NITROGEN COMPOUNDS,
    ETC, WHEN BURNED.

====================  Disposal Considerations  ====================

Waste Disposal Methods:MATERIAL COLLECTED ON ABSORBENT MATERIAL MAY BE
    DEPOSITED IN A POSTED TOXIC SUBSTANCE LANDFILL I/A/W LOCAL, STATE &
    FEDERAL REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.